The fuse panel is located below and to the left of the steering wheel by the brake pedal. For cigarette lighters and sockets, fuses numbered 9, 20 and 21 at 20A are responsible. Eautorepair.net redraws factory wiring diagrams in color and includes the component, splice and ground locations right in their diagrams. The wiring from the air conditioner control switch inside the vehicle carries less than 20 amps and grounds the relay to activate the air compressor. Generally, an AC pressure switch will go bad once or twice in a cars lifetime. 2012 Ford Explorer A/C Relays, Sensors & Switches CARiD.com But opting out of some of these cookies may affect your browsing experience. HELP, NEED AC RELAY LOCATION! - Ford Truck Enthusiasts Forums 2003 Toyota 4 cyl. The AC blower motor in Ford Explorer needs electricity to work. Fuse Box Diagram Ford Explorer (1996-2001) FlexOffers. I have a honda civic 1995 model carb type. Shop put on gauges,: lo side 30, but high side 400. Told me I have a blockage but didn't know where, suggested I clean out condenser fins. However, many components make up the air conditioning system, so your problem could be entirely different. 3) Blower flasher relay block - blower relay switched side - branches to fuse 7 in CJB. Motorcraft is the way to restore the performance of your vehicle. There are many ways to test a resistor, but the most easiest and basic method is to check the voltage at the electrical connector on the blower motor with a multimeter. Also, which one does my car take? Ford Explorer (from 2010) fuse box diagram, Engine cooling fan #1 high speed power, Engine cooling fan #1 and #2 low speed primary fuse, Engine cooling fan #1 and #2 low speed secondary fuse, Engine cooling fan #1 and #2 low speed relay #2, Engine cooling fan #1 high speed relay, Engine cooling fan #1 and #2 low speed relay #1, Vehicle power #2 (emission related powertrain components), Vehicle power #1 (powertrain control module), Vehicle power #3 (coil), All-wheel drive module, Air conditioning variable compressor control, Powertrain control module keep-alive power, Powertrain control module relay, Canister vent solenoid, Front blower relay coil, Electronic power assist steering module, Powertrain control module, Transmission control module, Engine control module (2.0L engine), Anti-lock brake system module, Plant EVAC and fill, Rear blower motor, Rear defroster, Trailer tow battery charge relays, Passenger compartment fuse panel run/start, One-touch up and down driver front window, One-touch up and down passenger front window, Interior demand lamps (overhead console, second row, cargo), Glove box lamp, Second and third row seat release, Visor lamps, 4-inch radio display, Power liftgate logic, Electronic finish panel, SYNC, Run/accessory relay (wipers, rear washer), Rain sensor, Interior courtesy lamps (overhead console, Second row, cargo), Puddle lamps, Console bin LED, Backlighting, Right turn lamps, Right trailer tow turn/stop lamps, Left turn lamps, Left trailer tow turn/stop lamps, Reverse lamps, Stop lamps, High-mounted stop lamp, Keypad illumination, Brake shift interlock, Start button run indicator, Passive anti-theft system, Powertrain control module wake-up, Rear seat power enable, Steering wheel control module, Intelligent access, Headlamp switch, Datalink connector, Steering wheel control module, Ignition switch, Push-button start switch, 110-volt AC power point, Power folding mirror, Power mirrors, One-touch up and down front windows, Door lock illumination, Memory switch illumination, Blind spot monitor, Rearview camera, Reverse sensing system, Lane departure warning module, Second row heated seats module, Heads-up display, Climate control humidity sensor, Terrain management system, Hill descent switch, Headlamp switch ignition sensor, Rear park lamps, License plate lamps, Trailer tow park lamps, Fog lamps, left and right turn signal mirror feed, Rear power windows, Passenger power window, One-touch down (driver side only), Driver window switch. It is probably either a bad compressor clutch or the system has lost its fluid and the low pressure switch is keeping it from coming on. 15A: 12: . When you increase or decrease the AC fan speed in your Explorer, the climate control unit signals the resistor module to increase or decrease the flow of electric current to the blower motor. 2014. How do I know its bad? # mpn4759626935. If either sides pressure gets too high or too low, it will shut off the power sent to the AC compressor and disable the air conditioning system. 2005 expedition: left front where the a/c relay is located - JustAnswer In this material, we will show an assignment of the 5th generation Ford Explorer fuse and relay boxes, produced in 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018, 2019, 2020. Pull the panel cover outward to access the fuses. Relays Ford Explorer MK2 - relay box - engine bay - USA version Ford Explorer MK2 - relay box - passenger bay - USA version WARNING: Terminal and harness assignments for individual connectors will vary depending on vehicle equipment level, model, and market. 34. Fuse Box Diagram Ford Explorer (2002-2005) You can drive your car with a bad AC pressure switch with no problem, but the AC system wont work. Windshield Wiper Relay Battery junction box. High pressure at 125. Ford Explorer AC blower motor not working causes and diagnosis, Ford F-150 AC blower motor not working - causes and diagnosis, Ford F-250 Super Duty AC blower motor not working - causes and diagnosis, Ford F-350 Super Duty AC blower motor not working - causes and diagnosis, Ford F-450 Super Duty AC blower motor not working - causes and diagnosis, Ford Mustang AC blower motor not working - causes and diagnosis, Ford EcoSport AC blower motor not working - causes and diagnosis, Ford Edge AC blower motor not working - causes and diagnosis, Ford Bronco AC blower motor not working - causes and diagnosis, Apple CarPlay on Range Rover, how to connect, Kia Seltos dirty cabin air filter symptoms, when to replace, Ford Edge horn not working causes and how to fix it, Jeep Gladiator bad alternator symptoms, how to check voltage, Rolls Royce Cullinan pulls to the left when driving, Cadillac XTS dirty cabin air filter symptoms, when to replace, Jaguar F-PACE bad mass air flow sensor (MAF) symptoms and causes, Honda Accord door makes a squeaking noise when opening or closing, Dodge Dakota pulls to the left when driving, Apple CarPlay on Jaguar XJ, how to connect, Apple CarPlay on Nissan Kicks, how to connect, How to use Power Running Boards on Toyota 4Runner, Kia Stonic makes clicking noise and wont start causes and how to fix it, Ferrari 296 GTB dashboard lights flicker and wont start causes and how to fix it, Hummer H3 key fob wont lock or unlock the doors, Jeep Renegade Apple CarPlay not working causes and how to fix it, Mercury Sable low AC refrigerant symptoms, how to recharge, Acura NSX AC blower motor not working causes and diagnosis, Fiat Tipo heater not working causes and diagnosis, MG5 burning smell causes and how to fix it. 2012 Ford Explorer, 2011 Ford Explorer . The cookies is used to store the user consent for the cookies in the category "Necessary". These cookies ensure basic functionalities and security features of the website, anonymously. Starter Relay battery junction box . This will bypass the relay and engage the A/C compressor and confirm that the relay is defective. Hi guys Posted: Apr 5, 2014. How the speed of the blower motor is controlled. First checked the relay and fuses and were all good. You can also use the code scanner to erase codes once you repair the problem. Other uncategorized cookies are those that are being analyzed and have not been classified into a category as yet. Check the owners manual of your Explorer or the fuse box cover to find the exact location of the fuse for the blower motor. ), AC Low Side Pressure Too High Common Causes & Repair Costs, 5 Signs Your Cars AC is Low on Freon (& What to do), AC Compressor Clutch is Not Engaging Causes & How to fix. Checking and Replacing Fuses Fuses and circuit breakers protect your vehicle's electrical system from overloading. Normally the AC pressure switch is closed when the pressure is correct and working properly. Ford Flex (2008 - 2015) - fuse box diagram (USA version - Auto Genius camry. Where is the oil pressure sending unit located on the 1990 ford explorer with a V6 2.3 engine? 1. Make sure you have the windows open, so the air doesnt cycle itself. I have a 2000 F250 7.3 Liter Diesel Super Duty Crew Cab. Rodents, such as rats or mice, can get under the hood or even make their way inside the dashboard of your Explorer and chew on wire coatings, which can cause all sorts of electrical problems. Year of production: 2010, 2011, 2012, 2013, 2014, 2015, 2016. So can it be the pressure switch thats stopping the power from coming through. Fuse specification chart :: Fuses :: Ford Explorer 2011-2023 Owner's Can the compressor run if the pressure switch is going out? She has an Associate of Science (paralegal) from Manchester Community College and studied computer science, criminology and education at University of Tampa. How Much Does an AC Recharge Cost? Fuse Box Diagram Ford Explorer (2011-2015) Never replace a broken fuse with anything other than a new fuse. Are there 2 switches on my car? The AC compressor is getting a command to turn on but is no longer able to, which would indicate that it needs replacing. WARNING: This product can expose you to chemicals including Phthalates, which is known to the State of California to cause cancer and birth . In this article, we consider the fifth-generation Ford Explorer (U502) before a facelift, produced from 2011 to 2015. Out of these, the cookies that are categorized as necessary are stored on your browser as they are essential for the working of basic functionalities of the website. Trailer tow brake controller. (& Is it Bad?). Insert the new relay, making sure you orient it properly so the legs fit into the proper cavities. For 2002-2012 Ford Explorer Rear Window Defogger Connector SMP 32288CW Functional cookies help to perform certain functionalities like sharing the content of the website on social media platforms, collect feedbacks, and other third-party features. Fuse MINI . Some of these symptoms are easier to diagnose than others, but there are a few AC system trouble codes that might lead you in the right direction. Before replacing fuses check that the key has been removed from the ignition and that all the services are switched off and/or disengaged. The 2012 Ford Explorer has 2 different fuse boxes: Passenger compartment fuse panel diagram. The AC pressure switches are located on the AC pipes on both sides of the AC compressor. If there are two wires, these are normally just a signal and a ground wire. There's lots more information on this site for your vehicle. Is it difficult to replace? Removed negative cable from battery when checking wiring. On older cars, it was more common for AC pressure switches to go bad. In this material, we will show an assignment of the 5th generation Ford Explorer fuse and relay boxes, produced in 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018, 2019, 2020. How to Disable the Alarm on a 2000 Ford How to Reset the Check Engine Light on How to Replace the Starter Relay on a How to Replace the Mega-Fuse in a Ford How to Reset the ECU After Changing an How to Turn Off the Check Engine Light 12 volt relais, relay image by Sascha Zlatkov from, Copyright 2023 Leaf Group Ltd. / Leaf Group Media. Battery drain or dead battery A failed ECM power relay can also cause a battery drain or dead battery. The power distribution box is located in the engine compartment. For cigarette lighters and USB sockets, there are fuses numbered 60, 62, 65 and 67 at 20A and 85 at 5A. Where is the starter relay located in a 2002 Explorer, 4 liter v6. 34 Answers. However, you should remove the AC pressure switch carefully to confirm that this is the case on your car model. Location : Passenger Side Notes : 12 volts; Blade type; 5-prong male terminal Type : Multi-purpose relay Condition : New Product Fit : Direct Fit Warranty : 1-year Replacement unlimited-mileage warranty Quantity Sold : Sold individually Prop 65 Warning : . When you turn on the air conditioning, you expect to feel cold air pour out. Always replace a fuse with one that has the specified amperage rating. Thank you for great details. Also, over time the bearings of the blower motor can lose their initial lubrication and begin to dry out, causing increased friction in the motor. Thanks. We're is the ac compressor relay located on a1992 Buick Riviera? Air Conditioning Recharge - Safely add freon to your AC system 5. The cookie is used to store the user consent for the cookies in the category "Other. This problem occurs when a leak occurs. The wiring on the other side of the relay handles about 300 amps. RELATED: 5 Signs Your Cars AC is Low on Freon (& What to do). Next day it was not working again. A struggling blower motor due to internal component degradation can put a lot of strain on the resistor when in operation, causing it to overheat and burnout. Alldatadiy.com offers redrawn diagrams as well as factory diagrams. It does not store any personal data. It is rippled with the battery and is covered by a protective cover. Auto/diesel mechanic. Make your beloved vehicle perform reliably, efficiently, and smoothly again with this top-grade A/C component from Santech. . Heated Relay Box 1 auxiliary relay box Park light Relay smart junction box (SJB). Toyota Ist 2G (2008 2016) fuse and relay, Toyota Estima Previa (2007 2020) fuse and relay, Toyota Alphard 2 (Vellfire 20) fuse and rel, Toyota Avalon (2013 2018) fuse and relay. How about when it stops working at all? -or- 2. When I initially start my car in the morning, my ac gives hot air. Fuse 7 is 5amp, output wire is YE/RD at CJB. It is safe to make the bypass of the pressure switch and i will manually turn my ac climate control on and off for it will not make the ac compressor always working for it is working effectively on cooling my car? Getting Started - Prepare for AC recharge Learn More > 2. First, did you check the ac relay? This shouldnt happen with the windows wide open. What does the AC pressure switch control? 2005 Ford Explorer V8 AC Inoperative. 2005 explorer 4.0.. where is the ac compressor fuse and relay located in the fuse box? Lets take a look at the most common signs. You can usually swap the horn relay with the ac relay to test if its bad. The function of the AC pressure switch is to provide safety monitoring over the AC system. 4. During this period, the Ford Explorer was updated 2 times. Follow this procedure after youve ruled out any problem with the blower motor fuse or relay. See other Ford Explorer: Ford Explorer (1996-2001)>> Ford Explorer (2002-2005)>> Ford Explorer (2006-2010)>> Forums Generation Specific Forums Damaged WAC relay (or CCRM). Question type: Maintenance & Repair. Replace Cap - Replace the AC low pressure port cap 6. Home Troubleshooting Ford Explorer AC blower motor not working causes and diagnosis. The ac mechanic told it is due to problem in sensor as air ia sufficient and asked to replace compressor and radiator as sensor is not available in market. This cookie is set by GDPR Cookie Consent plugin. Climate control module is the brain of the air-conditioning system in your Ford Explorer, also responsible for turning on and controlling the speed of the blower motor. Front AC blower not working | Ford Expedition Forum The blower motor is the central component of the air conditioning system in Ford Explorer, responsible for blowing hot or cold air through the AC vents. Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Explorer (U502; 2010, 2011, 2012, 2013, 2014, 2015). If the band is broken or melted, replace the fuse. But the ac clutch not coming on to blow out cold air. (Average by Model), 7 Symptoms Of A Bad Shift Solenoid and Replacement Cost, AC Low Side Pressure Too High Causes & Repair Costs, 5 Symptoms Of A Bad Car AC Condenser Fan and Replacement Cost, 5 Signs Of A Bad AC Compressor Clutch and Replacement Cost, 6 Symptoms Of A Bad AC Compressor and Location, 5 Symptoms Of Low Freon In Car and What to do, 3 Signs Of A Bad Neutral Safety Switch and Replacement Cost, 6 Symptoms Of A Bad Ignition Switch and Replacement Cost, Car Wont Accelerate But RPMs Go Up: Causes & Fixes. 2012. Fuse box diagram Ford Explorer 5G and relay with assignment and location The air conditioner uses high-amperage wiring, which could be dangerous if wired into the cab of the Explorer. However, you need to check a repair manual to confirm this for your particular car model. Blower motors can fail at any time without warning, but usually there are early signs before they stop working. So i decided to bypass tge pressure switch. In rare cases, a fault in the climate control unit can cause the blower motor to stop functioning properly. Open the Hood - How to pop the hood and prop it open 3. Most auto repairs shops charge between $75 and $150 per hour. If the relay shorts it can leave power on to the computer, even when the vehicle is turned off. 2011-2014 Ford Explorer Ac Heater Rear Climate Control Temperature Oem WE0SK (Fits: Ford Explorer) $35.37. Yes. 0. During this period, the Ford Explorer was updated 2 times. Labor: 1.0. To remove a fuse use the fuse puller tool provided on the fuse panel cover. Always disconnect the battery before servicing high current fuses. 2010 Ford Explorer Relay Locations - Ricks Free Auto Repair Advice - Answered by a verified Ford Mechanic. 2002 Ford Explorer: the Aux A/C Relay located and what number Thanks! 9 Causes Why Your Car AC is Not Blowing Cold Air, Does AC Stop Leak Sealer Work? If the pressure builds up too high, an explosion can occur in the system. If the volts reading is normal, it indicates a fault in the blower motor. He has been working as a car mechanic for over 10 years, and the majority of them specialized in advanced car diagnostics and troubleshooting. 2007 Ford Explorer Relay Locations - Ricks Free Auto Repair Advice Certified Automotive Diagnostic Technician. Castrol Edge vs. Mobil 1 Oil: Differences & Which Is Better? Are AC pressure switches normally open or closed? To check the fuse, pull it out of the fuse box using a fuse puller or needle nose plier and hold it against the light. Light on the inside is still blinking, no a/c and no voltage going to the switch on the compressor. Remove the electrical connector from the blower motor. How often do AC pressure switches go bad? Will it be helpful to change compressor or any other troubleshoot, No please, just look for the sensors on Ebay, changing the c ok compressor won't solve the problem since the one you have is working already. All Rights Reserved. Find many great new & used options and get the best deals for For 2002-2012 Ford Explorer Rear Window Defogger Connector SMP 32288CW 2003 2004 at the best online prices at eBay! Cigar lighter (power outlet) fuses in the Ford Explorer are the fuse 32 (110V AC power point) in the Instrument panel fuse box, and fuses 9 (Power point #2 (console rear)), 17 (110V AC power point), 20 (Power point #1/cigar lighter), 21 (Power point #3 (cargo area)), 27 (Power point (console)) in the Engine compartment fuse box. Low pressure at 105. Was: $113.99. It wasn't easy to replace while still on the vehicle but it can be done. There are many reasons why the AC blower motor may not be working in your Ford Explorer. The cookie is set by GDPR cookie consent to record the user consent for the cookies in the category "Functional". Analytical cookies are used to understand how visitors interact with the website. Vehicle power #3 (coil) - A/C clutch relay, Fan control relays, Variable air conditioning compressor, Auxiliary transmission warmup, Turbo charge waste-gate control, Electronic compressor bypass valve (for turbo charger), All-wheel drive module, Positive crackcase ventilation heater. My compressor clutch kicks in when I turn on the a/c. 2006. My engine fan stays on all the time regardless of the temperature. With the OBDII port on your vehicle, you can use a code scanner to check for DTCs. The most common symptom of a bad AC pressure switch is a faulty or intermittent air conditioning function. Fuse MINI . Without loosing any fluid. To become comfortable again, you will need to have the switch replaced. Free shipping on many items . Checked power to the compressor and its missing. Check a wiring diagram and repair manual before. 2015 Explorer will not start after being rear ended | Ford Explorer The fuse panel is located below and to the left of the steering wheel by the brake pedal. When replacing the AC pressure switch, in most cases you do not need to drain and refill the coolant system, because there is a check valve inside the AC pipe that does not allow the refrigerant to pour out even if you remove the AC pressure switch. Fuse box diagram (fuse layout), location and assignment of fuses and relays Ford Explorer (U502; 2010, 2011, 2012, 2013, 2014, 2015). If the motor does not spin after directly connecting to the battery, it confirms that the blower motor is dead and should be replaced with a new one. PCM Power Relay battery junction box . 2005 explorer 4.0.. where is the ac compressor fuse and relay located I took the car for repair in Auto Master and charged $145. You also have the option to opt-out of these cookies. 1998 Ford Explorer A/C Relays, Sensors & Switches CARiD.com RELATED: Does AC Stop Leak Sealer Work? On a 2002 Ford Explorer, where in the Aux A/C Relay located and what number? Engine compartment The power distribution box is located in the engine compartment. Average repair cost is $80 at 97,750 miles. Master window control switch Base, Passenger window control switch Base, Rear window control switches, 100 Body Control Module (BCM) 100 Power Steering Control Module (PSCM) 60 Engine Cooling fan motor, Get the BEST auto repair information Alldatadiy.com and Eautorepair.net are professional-grade shop manualsperiod. - Hi Guys, I would really appreciate some help on this. 5) Grounds at G200 - behind pass kick panel. Where is blower motor relay located on 1997 ford explorer . This 2012 Ford Explorer Fuse Box diagram post shows two fuse boxes; the Battery Junction Box/Power Distribution Box located under the hood and the Smart Junction Box/Passenger Compartment Fuse Panel. RELATED: 6 Symptoms of a Bad AC Compressor. Ford Explorer: AC Compressor Not Turning On - Diagnosis One-touch up and down driver front window, One-touch up and down passenger front window, Interior demand lamps (overhead console, second row, cargo), Glove box lamp, Second and third row seat release, Visor lamps, 4-inch radio display, Power liftgate logic, Electronic finish panel, SYNC, Run/accessory relay (wipers, rear washer), Rain sensor, Interior courtesy lamps (overhead console, Second row, cargo), Puddle lamps, Console bin LED, Backlighting, Right turn lamps, Right trailer tow tum/stop lamps, Left turn lamps, Left trailer tow tum/stop lamps, Reverse lamps, Stop lamps, High-mounted stop lamp, Keypad illumination, Brake shift interlock, Start button run indicator, Passive anti-theft system, Powertrain control module wake-up, Rear seat power enable, Steering wheel control module, Intelligent access, Headlamp switch, Datalink connector, Steering wheel control module, Ignition switch, Push-button start switch, Radio, 8 SYNC Multi-function display screen, SYNC module, Global positioning system module, 110-volt AC power point, Power folding mirror, Power mirrors, One-touch up and down front windows, Door lock illumination, Memory switch illumination, Blind spot monitor, Rearview camera, Reverse sensing system, Lane departure warning module, Second row heated seats module, Heads-up display, Climate control humidity sensor, Terrain management system, Hill descent switch, Headlamp switch ignition sensor, Rear park lamps, License plate lamps, Trailer tow park lamps, Fog lamps, left and right turn signal mirror feed, Circuit Breaker:Rear power windows, Passenger power window, One-touch down (driver side only), Driver window switch, 2013-2015:Engine cooling fan #1 high speed power, Engine cooling fan #1 and #2 low speed primary fuse, 2013-2015:Engine cooling fan #2 high speed fuse, 2013-2015:Engine cooling fan #1 and #2 low speed secondary fuse, Vehicle power #2 (emission related powertrain components'), 2013-2015:Vehicle power #4 (ignition coils), 2010-2012:Vehicle power #4 (ignition coils), 2013-2015:Vehicle power #1 (powertrain control module), 2010-2012:Vehicle power #1 (powertrain control module), Vehicle power #3 (coil), All-wheel drive module, Air conditioning variable compressor control, Powertrain control module keep-alive power, Powertrain control module relay, Canister vent solenoid, Front, blower relay coil, Electronic power assist steering module, Powertrain control module, Transmission control module, Engine control module (2.0L engine), Anti-lock brake system module, Plant EVAC and fill, Rear blower motor, Rear defroster, Trailer tow battery charge relays, Passenger compartment fuse panel run/start, 2013-2015:Engine cooling fan #2 high speed relay, 2013-2015:Engine cooling fan #1 and #2 low speed relay #2, 2013-2015:Engine cooling fan #1 high speed relay, Engine cooling fan #1 and #2 low speed relay #1.

Why Perm Processing Is Slow 2021, Karori Largest Suburb Southern Hemisphere, Tots Tv House Burned Down, Articles OTHER